Вплив частки коксового газу в паливі на необхідний рівень підігріву повітря горіння доменних повітронагрівачів при використанні їх теплоти димових газів

Ескіз недоступний

Дата

2016

ORCID

DOI

Науковий ступінь

Рівень дисертації

Шифр та назва спеціальності

Рада захисту

Установа захисту

Науковий керівник

Члени комітету

Видавець

НТУ "ХПІ"

Анотація

Запропоновано перед проектуванням системи утилізації теплоти димових газів доменних повітронагрівачів з теплового балансу згоряння палива встановити взаємозалежність необхідної температури підігріву повітря горіння повітронагрівачів та температуру підігріву повітря і доменного газу, збагаченого коксовим, одночасно від частки коксового газу в паливі. Розглянуто два температурних періоди: літній та зимній. Вставлено частку коксового газу, яку можна досягти внаслідок підігріву компонентів горіння доменних повітронагрівачів за рахунок системи утилізації теплоти димових газів повітронагрівачів.
To meet the increasing demand for energy saving, a heat exchanger must be applied in the hot blast generating system to recover the flue gas sensible heatfor the purpose of fuel gas and air preheating. Thefinal temperatures and fuel composition are included in the number of initial data for calculation of heat exchanger. It is very useful to determine interrelation of the coke gas share in thefuel with gas and air preheat temperatures before calculation - this is the purpose of the paper. Such determination was made using thefuel combustion heat balance equation. In this case the initial data were: the blastfurnace gas composition, the coke oven gas composition, the desired temperature under the dome of the hot blast stove, ambient temperatures for winter and summer conditions in the Ukraine. Part of the coke oven gas in the fuel was varied from 0 to 16%. Two cases of preheating were investigated.preheating of the combustion air only, preheating of combustion air and fuel at the same time. Each case was reviewed in the winter and summer conditions. As a result, a number of data were obtained. Out of this number optimal -variants were selected. It was concluded that combustion air preheating provides reducing of coke gas share in the fuel to 9-12%, and simultaneous preheating of combustion air and fuel provides reducing of coke gas share in the fuel to 7-9%. Such measures lead to substantial savings of expensive coke gas and can be achieved using a recuperative heat exchanger, because temperature of preheating varies from 178°C to 224°C. These results will serve as data forfurther calculation ofheat exchanger. At the same time further elimination of the coke oven gas is impossible as the temperature under the hot blast stove dome will not be achieved.

Опис

Ключові слова

металургійна галузь, доменний газ, утилізація теплоти, тепловий баланс, висококалорійні добавки, combustion air, coke oven gas, blastfurnace gas, waste heat recovery, heat balance

Бібліографічний опис

Заєць, О. М. Вплив частки коксового газу в паливі на необхідний рівень підігріву повітря горіння доменних повітронагрівачів при використанні їх теплоти димових газів / О. М. Заєць // Вісник Нац. техн. ун-ту "ХПІ" : зб. наук. пр. Сер. : Нові рішення в сучасних технологіях = Bulletin of National Technical University "KhPI" : coll. of sci. papers. Ser. : New solutions in modern technologies. – Харків : НТУ "ХПІ", 2016. – № 42 (1214). – С.

Зібрання